Indicates to apply molybdenum best(Containing more than 40% molydenum disulfide, NLG 1#2 or equivalent)
Indicates to apply molybdenum grease(Containing more than 30% molydenum disulfide, NLG 1#2 or equivalent) Molybdenum solution is made by mixing engine oil and molybdenumgrease as 1:1 mixing ratio. If there is no specific oil indicated, use the designated or recommended engine oil In case of special greases not written on above, they have not any specific symbols. The following abbreviations are used in this manual.
DAELIM S3 MANUAL MANUAL
The following symbols are used in this manual to represent job-related warnings or cautions May result if instruction are not followed Serious accidents may result if instructions are not Used at the time of measuring the compression power of cylinder Used at the time of disassembling the cir clip of master cylinder 15 Used at the time of disassembling steering head top thread Used at the time of inputting the oil seal of front fork Used at the time of pressing bottom cone race to steering stem Used at the time of disassembling top blace and bottom ball race Used at thetime of assembling crank shaft to crank case Used at the time of disassembling bearings of crank case Used at the time of replacing valve guide Used for disassembly ACG Rotor from Crank shaft (SH Flange bolt included) (SH TYPE included) SH(Small Head) : presents 6mm bolt of 8mm flange head
Torque values for other items are listed in the following tables.ĤBOLT, NUT 4SCREW5BOLT, NUT 5SCREW6BOLT, NUT 6SCREWĨBOLT, NUT 6FLANGE BOLT,NUT10BOLT, NUT 8FLANGE BOLT,NUT12BOLT, NUT 10FLANGE BOLT,NUT Torque values listed above ate for specific tightening points.
DAELIM S3 MANUAL GENERATOR
IGNITION SYSTEM IGNITION TIMING IDLE AC GENERATOR BATTERYCAPACITYSPARK PLUG SPARK PLUG GAPFUSE CAPACITYSTARTING SYSTEM HEADLIGHT(HIGH / LOW)POSITION LAMPWINKERSTAIL/STOPLAMPCOMBI METER LAMP(SPEEDOMETER/TACHOMETER)NEUTRALINDICATOR LAMPHIGH BEAM INDICATOR LAMPTURN SIGNALINDICATOR LAMPNUMBER PLATE POSITION LAMPTACHOMETER LAMP REPLACEMENTLUBRICATION AIR CLEANER VALVES VALVE SYSTEM INTAKE VALVE IN VALVE OPENĪir cooled 4cycle DOHC engine (4 valves)1(single cylinder), front angle 8056.5mm49.5mm124cm3ġ1.8:113.0kg/cm2(600 rpm)1.30L(Full capacity)1.10L(at changing)0.1L(Full capacity)Forced pressure splash typeDry filter paper DOHC chain operationDOHC 4 Valves15BTDC39ABDC57.4BBDC12.6ATDC0.150.02mm0.230.02mm38kgĬLUTCH TRANSMISSION TRANSMISSION PRIMARYREDUCTION RATIO TRANSMISSION SECONDARYREDUCTION RATIO
DAELIM S3 MANUAL FULL
TYPE CYLINDERS, ARRANGEMENTBORE X STROKE DISPLACEMENTCOMPRESSION RATIO COMPRESSION PRESSURE OILCAPACITY FULL REAR FRONT BRAKE REAR BRAKE FUELTANK CAPACITY Full capacity TYPEFRONT SUSPENSION/ STROKE REAR SUSPENSION/ STROKE FRONTTIRE SIZEREAR TIRE SIZETIRE PRESSURE 1 person FRONT OVERALLLENGTHOVERALLWIDTHOVERALLHEIGHTWHEELBASESEAT HEIGHTGROUND CLEARANCE DRYWEIGHTGROSS WEIGHTĢ,110 mm 750 mm1,200 mm1,500 mm745 mm136 mm159 kgs170 kgsĢ,140 mm750 mm1,215 mm1,500 mm762 mm143 mm159 kgs170 kgs DAERIM MOTOR Co., LTD.All Rights Reserved CRANK CASE COVER / CONTINOUSLY VARIABLE TRANSMISSIONĬopyright 2010.